Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ General Discussion Forum > Air-Lift 1000 Suspension??

Join Wrangler Forum Today


Thread: Air-Lift 1000 Suspension?? Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
03-17-2011 08:17 AM
UnlimitedLJ04
Quote:
Originally Posted by Got 4 Lo View Post
It lifts the body but does not help with ground clearence
huh? you're talking about body lifts?
03-17-2011 06:29 AM
Got 4 Lo It lifts the body but does not help with ground clearence
03-16-2011 08:56 AM
Peepers Reading the instructions seems pretty straight forward. I know a lot of people that use kits like that in motorhomes for a little extra support. I'll be installing a set in a E350 van within a few weeks.
03-16-2011 08:50 AM
UnlimitedLJ04 These work in addition to coils to prevent rear end sag and help carry heavier loads better...not for lifting the vehicle at all...
You need to set the bumpstops for the lift height. so pull the springs & jounce bumper, fully compress the axle on both sides, make sure the shocks aren't bottoming out, check gas tank vs diff cover clearance, check bump alignment, etc.

follow this thread: http://www.wranglerforum.com/f5/corr...gth-70047.html

then once you know what bumpstop extension you need, and get it installed, reinstall the springs and shocks and set the Jeep at ride height.

measure inside diameter of the coils, and the bump height to the bumpstop cup. call up AirLift and tell them those dimensions, and they'll give you a part number to make it all fit.
Parts should be about ~$100, for a shrader valve that can be filled by an external compressor. or you can spend more money for fancy on board compressers and such. max psi is about 35psi for AirLift 1000, so no sense in using a York or something...the AirLift compressor, or a Rancho 9000 shock compressor will work fine and avoid the mess of trying to get a heavy duty onboard with regulator working for this application.

Here's my Airlift bags in the rear:

brass T from hardware store, and black polyethylene tubing (outdoor irrigation tubing)

^i tried the clear PE tubing...don't use it, more brittle in cold and cracks.
tube routing:

Shrader valve:

I ended up needing to modify the jounce bumpers.



So how do they work?
Normal ride height:

Sagged 3" with ~600+lbs of cargo:


Got an inch back with 20psi:

It drove far more stable and didn't bottom out at all with the Airbags pumped up. No more wishy washy rear when loaded, and no more bottoming out

Here's another write up on AirLift bags:
Jeep TJ Air Lift Suspension Installation Write-Up
03-16-2011 08:09 AM
Got 4 Lo Teah i wanted to do the same thing because when i have people in the back it sags and it not good when i am offroading.
01-14-2009 10:02 PM
mikereednv
Air-Lift 1000 Suspension??

Has anyone used an Air-Lift 1000 suspension on the front of a TJ? I am looking to increase the front load capacity, as I have a plow on my 2002 Wrangler X. The vehicle needs a bit of help in the load capacity. Is there another make that might be better? How rough a job is it to install? Thanks for the help.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 07:39 AM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC