Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ General Discussion Forum > Jeep wrangler unlimited rubi gas tank size?

Join Wrangler Forum Today


Thread: Jeep wrangler unlimited rubi gas tank size? Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
12-20-2011 10:53 AM
JBD It is the sender, not the gauge. Remember that the fuel pump is in the tank and is cooled by the fuel in the tank. Running the tank empty in not a good thing to do as the pump will start running hotter, and then go out. You should fill your tank at 1/4 or about 5 gal. left in tank. It wont hurt to run low once in awhile but not a good habbit.
12-20-2011 09:45 AM
muldrow The vent tube in the tank is getting covered up by fuel when you fill it, and that's triggering the pump to stop filling the tank up. My LJ is doing the same thing. There's a pretty good thread here about the "vent tube mod": http://www.wranglerforum.com/f118/19...9-a-94857.html
12-08-2011 08:49 AM
krisak
Quote:
Originally Posted by kylekae View Post
I'm pretty sure its not the gauge it has to be some components in the tank that.measure how.much.gas is in the tank if I have a 19 gallon tank I want the light to come on at 17 right now my light comes Omar about 12.5 to.13 gallons I will ask my mechanic tomorrow
Do you also end up with the needle sitting at full for a few gallons before it begins to move? If so, then the gauge can possibly be adjusted so that it works correctly.

You have a gauge that can display 0 to 100.
The sender is sending values of 20 to 120.
So the fix is to drop the values that are being sent by 20. (As I said earlier, possibly by just putting a small resistor inline.)

The non-linearity of the floats/sender I don't have any ideas on.
12-07-2011 10:25 PM
kylekae I'm pretty sure its not the gauge it has to be some components in the tank that.measure how.much.gas is in the tank if I have a 19 gallon tank I want the light to come on at 17 right now my light comes Omar about 12.5 to.13 gallons I will ask my mechanic tomorrow
12-07-2011 06:29 PM
KKhamesi ooo interesting
12-07-2011 04:22 PM
freeskier
Quote:
Originally Posted by KKhamesi View Post
dont different years have a smaller gas tank? i thought 97-99 they put 15 gals and 19 in 00-06
Nope. And even at that the 15 and 19 gallon tanks were exactly the same, except the filler tube extended into the tank further to limit capacity.
12-07-2011 04:11 PM
village idiot They're all inaccurate to a degree. Replacing the gauge won't fix anything, it'll still do the same thing. Mine's exactly like yours. When my light comes on I put in about 15 gallons to fill. All it means to me is I can still drive 40 or 50 miles after the light comes on before it comes to a halt. And actually I think that's the idea with a low fuel warning light anyway, it's supposed to come on in time to still allow you to drive a ways to get to a gas station.
12-07-2011 02:58 PM
GoldenSahara00 I stay on full for almost half of my total miles.
12-07-2011 02:48 PM
jgorm It really depends on the jeep, and the tilt of the road at the station. My 02TJ would kick on the light way before my 06 LJ. My 06 is close, when the light comes on I put in about 16.5 gallons. On my 02 it would only take about 14 when the light came on.
12-07-2011 02:42 PM
TJWenatchee
Quote:
Originally Posted by KKhamesi View Post
its the gauge becuz when i fill up it goes way past F and i can run on E for some time... i usually fill up 16 gals. and sometimes it likes to go up and down depending on her mood
x2 on her mood. Mine will read full when it's full for a few months. Now it's gone back the other way, at full will only read 3/4 of tank. One day I know it will work the other way again. I just use the trip odometer.
12-07-2011 10:49 AM
krisak
Quote:
Originally Posted by kylekae View Post
How can this can be fixed?
I was thinking about this a bit this morning while driving to work. I remember older vehicle were (I believe) resistance based. So in theory, a slightly stringer resister on the line from the sender could align the gauge a bit better.

However, with Jeep's irritating over-computerization of everything, I'm not entirely sure if that would work. Might be worth a try. Someone could just get under there with a multimeter and measure the values between full and empty.
12-06-2011 03:34 PM
kylekae How can this can be fixed?
12-06-2011 02:21 PM
John in Vegas
Quote:
Originally Posted by mannyssj13
I have the same problem normal fill my jeep up when it gets to 1/4 of a tank but only takes 13 or 14 gallons even the one time i let the gas light turn on didn't fill up close to 19. Can this be fixed? Really don't care to much but would be nice to have a fully working gas gauge.
If you need to put 3/4 of a tank in to fill it and can only fit 13 gallons, that's not bad considering the math says you only need 14.25 gallons
12-06-2011 01:59 PM
KKhamesi dont different years have a smaller gas tank? i thought 97-99 they put 15 gals and 19 in 00-06
12-06-2011 01:56 PM
rayman375 I can only putabout 13 gallons in mine with the fuel light on, I thought the specs were wrong that I was reading on the net.
12-06-2011 01:55 PM
KKhamesi its the gauge becuz when i fill up it goes way past F and i can run on E for some time... i usually fill up 16 gals. and sometimes it likes to go up and down depending on her mood
12-06-2011 12:50 PM
MikeMTJ I drove 30 miles after my fuel light came on, and I was only able to put 15.3 gallons in on my last fill up.
12-06-2011 12:40 PM
mannyssj13 I have the same problem normal fill my jeep up when it gets to 1/4 of a tank but only takes 13 or 14 gallons even the one time i let the gas light turn on didn't fill up close to 19. Can this be fixed? Really don't care to much but would be nice to have a fully working gas gauge.
12-06-2011 11:03 AM
krisak A friend and I were discussing this and it's probably more related to the sender. There's a bit of a weird curve that I'm guessing has to do with the mounting arm on the floats (do they still use floats). Also, there seems to be a bit of randomness between one Jeep and the next.

My '05 Rubicon Unlimited is fairly linear and seems to be reasonably accurate, even near the bottom of the tank. My gauge does seem to accelerate below 3/4 of a tank, but not by a whole lot.

His '03 Sahara is decidedly non-linear. When his gauge reads 1/4 tank, he's pretty much making a beeline for the nearest gas station.

Mine on empty and his just starting into the red take about the same amount to fill.
12-05-2011 04:26 PM
kylekae That's really strange. So its a 19 Gallon tank but it has a bad fuel gauge. If I replace the gauge will it fix that problem
12-04-2011 07:53 PM
56cj5 It could very well be a factory foul up. It's been known to happen. My 2006 se 4 banner has a 19 gallon. And it probably shouldn't. But when I fill up it goes right up to 17 or 18 gallons. But that's after line four days below the red zone!
12-04-2011 07:51 PM
Lbailey21 its the gas meter. they hold 19 but when my gage says its dead empty i still go 50 miles.
12-04-2011 07:26 PM
Zeep 19 Gallons. Fuel gauges are known to be crap on TJ/LJ's. Use your trip meter, you'll get used to it!
12-04-2011 07:05 PM
kylekae
Jeep wrangler unlimited rubi gas tank size?

I have a 2006 jeep wrangler unlimited rubicon. Every time I fill it up, the gas nozzle automatically stops at almost 13. The fuel tank gauge says it full. Online all of the specs from tons of web sites say that it has a 19 gallon tank. I am pretty sure the gas tank is stock. What is going on I have a 13 gallon tank where I think I should have a 19 gallon tank. What you guys think about this.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 08:56 PM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC