Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ General Discussion Forum > Jeep is still whistling

Join Wrangler Forum Today


Thread: Jeep is still whistling Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
04-23-2009 05:25 PM
surfcape thanks again, i can't want to check if thats whats making the noise, its starting to get dark hear on capecod so i'll have to wait until tomorrow. wish me luck
04-23-2009 02:33 PM
nater344 The determining factor that made me finially realize it was the intake manifold was when I pushed down on the top of the air box (directly above the intake manifold connected to the throttle body)(while running) and the squeal changed it pitch.

Since I tightened the intake manifold up I no longer have any squeal, my Idle dropped (it was a bit high) and my gas mileage has improved.

I hope this helps!
04-23-2009 02:28 PM
nater344 I used a 1/2 inch rachet with different extensions from underneath the Jeep (on a creaper). It takes a bit of patience, but you can get it from underneath with the right tools. Make sure you check all of the intake manifold bolts...some are hiding. Let me know how you make out!
04-23-2009 12:24 PM
surfcape Sweet, thanks man. It has been a long problem. On page two of this forum is the other things that I have tried and that were suggested, I thought that it could have been the injectors or bearings in the pulleys, but the something is telling me that even though it sounds like the noise if from the compressor its my intake manifold because it bolts down so close. Just ran out at lunch to look find what i should check at my break, but was wondering how to access the bolts under the manifold without removing everything.
04-23-2009 08:01 AM
nater344 Surfcape - Try tightening up up the intake manifold where it connects to the engine (Don't forget the bolts underneath). Mine did the exact same thing and took several hours to find that the engine was sucking air in between the engine and the intake manifold....horrible squealing noise that went away when you press the gas and came back at idle. Try that and let us know.
04-22-2009 08:18 PM
surfcape No i have not taken the belt off to specifically check the pulleys, but a local shop has had it in twice and said that there was no problem with the pulleys. Worth checking on my own though. I've had this problem for several months and now i finally have pinpointed the noise directly within inches of the compressor using a mechanics stethoscope. The jeep shops all said its a vacum leak but we can't find it. It is an ear splitting frequency and nothing changes the noise except pressing on the gas pedal.
04-22-2009 06:58 PM
slf41002 Have you pulled the belt off and started it just for a minute or so to see if it is one of the item the belt turns??? Could be the alternator bearing,could be the A/C compressor,could be an idler pulley.I would start by pulling the belt after the engine has been off for a few hours then start for just a minute or two to see if that is what it is.If the noise it gone then shut it off an spin each pulley by hand to see if you can hear anything.
04-22-2009 05:07 PM
surfcape
Jeep is still whistling

I had posted a question a few months ago on how to stop my jeep from whistling when I let off the gas, but its a long thread. i gave up on solving the problem and had checked every suggestion but to no avail. I recently had a friend who has a mechanics stethoscope. Its been in several shops who can't find it and it took me several months to track down the noise, because it is intermittent and stops after a few minutes of idling. The noise is coming from around my compressor, within an inch or two, so could it be the pulley, compressor clutch, or a bearing. what should i check first? Any one experience this. i'll try to find my old thread if i can. thank you much.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 11:48 AM.



Jeep, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC