Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ Tech Forum > Knocking underneath driver side / front

Join Wrangler Forum Today


Thread: Knocking underneath driver side / front Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
09-30-2013 08:06 PM
Tip and Ring
Same Thing Here !

My 02 TJ with a 1" body lift started doing this the other day. The noise and a slight tap can be felt/heard at the gas pedal area. I have used a Teraflex Linkage adaptor, and had to do a lot of adjustment. I have replaced the head about 5,000 miles ago due to an overheat and head crack (old 0331) I replaced all of the gaskets when I did this and installed the head with the intake/exhaust manifold attached. I was worried about gaining an angle for the torque down. I pulled the front driveshaft tonight with the idea that one of the joints in the shaft was binding but the noise returned. I am going to try these fixes you guys mentioned. Anybody have any other ideas?
09-18-2013 10:43 PM
MatthewC85 Nope , sounded like a gas leak which is... 95% probably what it is. Ill have to remove the manifold and give it a check if its not that its the gasket. Id seafoam it if i didn't just change the oil .It only makes the tick/knock at full load while in drive. if you drive normally without flooring the 4 banger or going up a steep hill it really wouldn't be a problem for concern , just i live in a hilly area and its become someone of a nuisance for me hearing a 2.5L sound like a diesel. The crack must be hairline for now which is why in neutral or park flooring it the sound is faint to non existent. Its only apparent when you hit the gas hard while in drive.

If however this is not the problem I believe my head will explode.
09-18-2013 09:31 PM
jherrington Does it sound like a rattle? Like a marble in a can?
09-18-2013 06:12 PM
MatthewC85 Update . Checked it out further and we narrowed it down to the manifold gasket or manifold itself. buddy of mine told me not to deal with it now to continue driving with it the way it is. Ill upload a video in a few.
09-17-2013 12:32 AM
BlaknBlu Mine was where the TC shift linkage attaches to the tub under right foot. I had to pull back the carpet to get to the bolts inside, hold them while someone tightened from underneath.
09-17-2013 12:17 AM
Owen_TJ i definitely think its your linkage...

good luck with it tomorrow
09-17-2013 12:10 AM
MatthewC85 Ill give the test a shot tomorrow. im also going to try and record a video of the noise. post it up on this thread. Thanks

as for your first question yes , I am lifted 3.25 inch or basically a budget boost with a spacer to 3.25. the linkage was adjusted when i did the lift about 4 or so years ago the shocks were recently changed that's about it.
09-17-2013 12:02 AM
Owen_TJ My vote is still the tcase linkage...are you lifted??? have you adjusted the linkage at all?

go under it, loosen the bolt on the linkage, then have someone hold the lever down inside the vehicle while you tighten it.

Or, as a little test, try to slightly pull up on the tcase lever (quarter to half inch) and see if the vibration/noise goes away.

I used to have a vibration and when i adjusted the linkage it went away.
09-16-2013 11:59 PM
MatthewC85 just to add the noise is more front end. to narrow it even more probably near my foot when the gas pedal is being pressed the knock is not felt ( floor is not shaking) its more just heard. which is why i automatically thought manifold gasket or the manifold itself. however the noise is not apparent in neutral or park which threw me a curve ball.
09-16-2013 11:53 PM
MatthewC85 checked that out the other day looked fine also there is no vibration in the shifter and it shifts perfectly . any other ideas?
09-16-2013 11:52 PM
BlaknBlu
Quote:
Originally Posted by brs256 View Post
look at your transfer case shifter linkage ... slop will cause a knocking sound
yep, I had to tighten mine up to get rid of the knocking noise.
09-16-2013 11:51 PM
Owen_TJ
Quote:
Originally Posted by brs256 View Post
look at your transfer case shifter linkage ... slop will cause a knocking sound
this...
09-16-2013 11:34 PM
brs256 look at your transfer case shifter linkage ... slop will cause a knocking sound
09-16-2013 10:29 PM
MatthewC85
Knocking underneath driver side / front

Jeep started knocking only during hard acceleration about a week or two ago. does not make the noise in park or neutral ( I can rev the crap out of the engine no noise) nor does it make a noise while driving under normal circumstances (slow acceleration normal day to day driving). It can be only heard up hill / highway speed acceleration , could this be a slight leak in the manifold or something drive shaft U-joint related? Reason im leaning towards manifold is the location of the knocking/clicking noise and to me it just sounds like a gas leak however im asking this question because -- can a gas leak in the manifold area be only heard under heavy load and not under high rev in neutral or park? doesn't make much sense to me which than makes me lean towards driveshaft?

Jeep Tj 181 000km rebuilt engine at 145 000km
2.5L
1998

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 04:56 AM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC