Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > YJ Jeep Wrangler Forum > YJ Tech Forum > Brakes Weirdness: Need some help here.

Join Wrangler Forum Today

Thread: Brakes Weirdness: Need some help here. Reply to Thread
Post Icons
You may choose an icon for your message from the following list:

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Please enter a password for your user account. Note that passwords are case-sensitive.
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:


Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.

Additional Options
Miscellaneous Options

Topic Review (Newest First)
07-21-2010 08:11 AM
FyreSarge @ hannahuffster: Did you have any problems bleeding the brakes after replacing calipers and hoses? I have flowed about 3 quarts of fluid trying to get a good pedal.
06-20-2010 12:43 AM
AlexPerdido Wow, great responses and great advice. Many thanks. I will definitely give those soft hoses some attention. Anybody else have thoughts on this?
06-19-2010 11:58 PM
beachnjeep true, always in pairs to be safe
06-19-2010 11:42 PM
hannahuffster agreed with just about everything that has been said. I had the same problem when I got my 93. pulled one way while driving and veered to the other when breaking (especially above 35-40 mph). Changed calipers & soft lines [and went ahead and replaced pads and rotors so everything is new] and now it drives like a Cadillac! I would go ahead and change both calipers and lines when you do it, just to make sure the other doesnt start hanging with one new caliper.
06-19-2010 10:24 PM
beachnjeep dang you typed faster then me
06-19-2010 10:23 PM
beachnjeep if it pulled right hard then you must have had a stuck caliper most likely or a faulty hose(one of the most overlooked items). Yes it can go away as it cools off but might start again as it heats up. Pads at first will not be noticible till it does it a few times. Hopefully they tried to look at the inner pad not just the outer.
Inner pad wear: caliper sticking usually
Outer pad wear: slide mechanism not letting caliper float back and forth as brake is applied.
I would double check and ask them if they looked at the inner pad as most shops can miss that on a quick glance.
06-19-2010 10:22 PM
Pylonpounder The rubber brake hoses are too old and going soft. This happened to me; they won't seem soft, you won't be able to squish them really, but they are soft enough that they swell under the pressure of braking and, after a little bit of driving and, consequentially, using brakes, they hold enough pressure that it's noticeable. Took me two drives to figure it out cuz the first time wasn't long enough for the brakes to start smoking, which is what allerted me, silly me. Check out your hard brake lines too, just to be safe. I blew one troubleshooting when this problem happened to me. the soft brake hoses run from the brake calipers to the hard lines. Quadratec or JCwhitney probably both have them for relatively cheap
06-19-2010 09:58 PM
Brakes Weirdness: Need some help here.

This is my first post, although I often read this forum. Always learn something.

Driving my '95 YJ yesterday, top off, in the sun, loving life. Gradually I notice the engine is struggling a bit, and there's an acrid hot-metal smell. Slow-rolling in neutral, the Jeep stops on a dime like I've stepepd on the brake pedal. Now it's pulling sharply to the right at the slightest press of the brakes, and the funky smell is bad and getting worse. Oh, crap...the brakes are stuck! I drive, slowly and terrified, to my tire shop that also does tuneups and brake jobs, and leave the Jeep there with a full description of the problem. First thing next morning, shop guy calls and says they cannot reproduce the problem. Brakes are working fine. Furthermore, he says he took off the wheels, and the brake pads show no sign of overheating: no glaze, no hot spots, rotors look good. I go the shop, fire up the Jeep, sure enough, everything's perfect. I cannot express my frustration.

Has anyone had this problem, or can share there first thoughts on this weird brake thing? Now I'm nervous about driving the Jeep.

Please advise and thanks from Atlanta.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

All times are GMT -5. The time now is 10:29 PM.

Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC. is not in any way associated with the Chrysler Motors LLC