|12-15-2010 02:31 AM|
Once a sealed (as the factory builds it) CV goes bad, it needs to be replaced. I simply would take the front driveshaft to your local driveshaft repair shop (there are 2 within 10 miles of my house and 4-5 within 30 miles so there are likely a few close to you) and have them rebuild it, and specify they use Spicer parts.
|12-15-2010 01:34 AM|
Thanks everyone for the awesome rapid info!!
|12-14-2010 09:56 PM|
|12-14-2010 09:13 PM|
I had the angry sparrow too when I first bought mine. 2 front hubs, front axle ujoints, front driveshaft u joint and front driveshaft CV later all is quiet.
One of the front axle joints was really bad.
The CV joint wasn't, until I tried to clean it and spit needle bearings all over my garage floor.
|12-14-2010 01:52 PM|
|geiman||Same situation; after a day at Rausch Creek I would get a chirping/squeaking as the tires rotated. Turned out to be the CV on my front drive shaft. Took the front drive shaft off and drove it to make sure; it probably needs to be rebuilt, but after cleaning it and re-greasing it as best as I could (no grease fittings on stock CV for a 98 TJ) it doesn't squeak anymore. We hit more mud that day than usual, so I'm guessing I just managed to get the CV pretty dirty and it needed to be cleaned. I've got parts on the way to rebuild it since they are relatively cheap, but its been fine for about 2 weeks now. Search for angry sparrows and you should find a good bit of information (if thats your problem as well).|
|12-14-2010 01:20 PM|
|jeepjones||It could be the front wheel bearing hub units, front axle shaft U joints,drive shaft u joints or the Double Cardan Joint (which is a type of CV) at the transfer case. If you have a SYE it might be the double cardan on the rear drive shaft.|
|12-14-2010 01:12 PM|
CV joints? dont TJ's have U-joints?
Im thinking the wheel bearings.
|12-14-2010 12:58 PM|
Pretty good chance it is the CV joint. Do you have CV DriveShafts F&R? If so, what kind of rear shaft do you have and does it have a greasable center ball? I've got Tom Wood's DS F&R and they are fully greasable . . . and you really have to keep on top of that Center Ball and keep it lubed or it'll wear out pretty quick. I already had the rear rebuilt once after the center ball went bad and noticed a noise a few weeks ago and am hoping that I caught it in time and got grease in there before it started to wear . . . so far so good . . . I've put about 600 miles on it and the noise has not returned . . . last time I didn't know what the noise was or that I was supposed to grease the center ball and about 200 miles after first noticing the noise, the DS was flopping all over the place, had a ton of play and I was lucky it didn't come loose on me. I also replaced the stock front DS after having a case of the "angry sparrows" (a chirping, squeaking noise, that usually means the center ball in the front DS is going bad).
A word of caution . . . a DS failure can cause big time damage and be very dangerous . . . figure it out and address the issue quick. Luckily it's pretty easy to diagnose . . . pull the rear shaft and drive around in 4x4 if you think it's the rear . . . if it's still there put the rear back on and pull the front off. Could be something else, but I'd start by checking the DS as it's a pretty easy to diagnose if that is the issue.
|12-14-2010 12:17 PM|
Squeaking CV Joint??
My wrangler started squeaking pretty bad a few weeks ago. It started a day or two after I went offroading. It's a metallic squeaking noise that is only present when the wheels are rolling (i.e. car must be moving, not just in gear or turned on). I took it to one place and we put it on a lift. The squeaking wasn't present when the wheels spun on the lift if that tells you anything.
Anyway, another place I took it to is saying it's probably a bad CV joint. Everything I hear about CV joints is that they make a "grumbling" or clicking noise and that it occurs when turning, at least in the beginning.
Is this my problem??? Or is there another culprit.
Wrangler 06, 4" lift, 35s.
Thanks for any help!