Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > YJ Jeep Wrangler Forum > YJ Tech Forum > Voltage Regulator/Alternator problem??

Join Wrangler Forum Today


Thread: Voltage Regulator/Alternator problem?? Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
11-21-2011 12:57 PM
Mictrik
Quote:
Originally Posted by Garyk View Post
Change the battery, can't believe the battery lasted this long....it takes a certain amount of "minimum voltage" to run the engine, I think it may still be 11.5 volts...
I know, I never gave it much thought but the Jeep is a 2004 and it is the original Mopar 600 CCA battery. The jeep only has 59,000 miles on it, has been kept in a garage and has been extremely well maintained. This is why it has lasted so long (& luck). The low idle is due to lack of (not enough) exciter current at idle when the battery has been drained. I decided 8 years was enough and headed to Costco to pickup an Optima Blue top. The trip to Costco sufficiently charged the battery because by the time i got there idle was perfect and this was good news since they had no Optima's at all. After reading various posts I have decided to go with the Die hard Platinum 34M, meanwhile I placed my battery on a charger overnight and it again performing perfectly..???. as it passed a load test. The battery did supply power to the high beams & fogs for 40 minutes before it was drained low enough to click the starter. I am still going to replace it for winter but would like to find a better price than 219.00 for the DH platinum. I really think that price is a bit ridiculous.
11-18-2011 07:03 PM
Garyk Change the battery, can't believe the battery lasted this long....it takes a certain amount of "minimum voltage" to run the engine, I think it may still be 11.5 volts...
11-18-2011 11:00 AM
kik [QUOTE=Mictrik;1754120]I was looking into an issue with my jeep (2004 TJ) suddenly displaying very low idle once warmed up. This became evident immediately after the battery was drained too low to start by leaving the lights on. Battery is original and about 8 years old now. Any advice on this would be appreciated...

I'm not sure about the low idle, but if you were lucky enough to get 8 yrs. out of a battery, which is still hard to believe, then you need to replace it yesterday.
11-18-2011 05:46 AM
Mictrik I was looking into an issue with my jeep (2004 TJ) suddenly displaying very low idle once warmed up. This became evident immediately after the battery was drained too low to start by leaving the lights on. Battery is original and about 8 years old now. Any advice on this would be appreciated...

That said, I was looking through the service manual and found something relative to this post. Voltage regulation is governed by a circuit in the PCM module. The Voltage regulation circuit uses the battery temperature sensor located under the battery on the battery tray to determine the charging voltage applied. The manual states, "System voltage will be higher at colder temperatures and is gradually reduced at warmer temperatures." This is consistent with what your gauges display and seems to indicate normal operation...
01-25-2011 03:35 PM
Rastaman69 Thanks for the info. I'm going to try tightening up my connections tonight and see what happen.

@ kik - Good call, I should have provided that info in original post. Battery is 1 yr old & I can't remember cca but it's high. I have the warranty so will probably return this battery & get a new one if tightening connections doesn't change anything.
01-23-2011 08:26 AM
kik You didn't provide any information regarding the age of the battery and the cca. If it's over 3 yrs. old and doing that in cold weather; first check the connections. If it's still doing it I would install a new battery. I don't like getting stuck because of a bad battery.
01-23-2011 02:39 AM
armadillo My '91 did that just before the battery died.
01-22-2011 10:34 PM
J10 Mine did a similar thing except it was more drastic. Fixed by cleaning and tightening loose battery terminals. It was fine in the summer though cause the metal expanded just right to tighten it up. The cold made it loosen up just enough
01-22-2011 09:45 PM
Mike_3303 As long as the volts go down I personaly wouldnt worry about it. If they climb and peak while you're driving then I would have it looked at. My jeep acts up too when it gets cold. Its lovely 0 degrees where I'm at
01-22-2011 09:36 PM
Rastaman69
Voltage Regulator/Alternator problem??

The first pic is the "normal" charge that I see all the time and the second pic is what has been happening lately at startup now that its freezing cold outside. Once the Jeep warms up to operating temp the charge drops back to the first pic range. May be nothing at all and its been this way forever and I just didn't notice before or there may be a problem...what say y'all? I was thinking it may be my voltage regulator going bad or alternator (still OEM) slowly dying.

pic #1 "Normal"

Attachment 35650

pic #2 "Cold temp"

Attachment 35651

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 03:17 AM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC