Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ General Discussion Forum > Fuel problems

Join Wrangler Forum Today

Thread: Fuel problems Reply to Thread
Post Icons
You may choose an icon for your message from the following list:

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Please enter a password for your user account. Note that passwords are case-sensitive.
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:


Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.

Additional Options
Miscellaneous Options

Topic Review (Newest First)
05-28-2011 08:23 PM
jmpierce Jerry it's s only a 2003 I just bought it after it set up and was rarely driven in two years looks like partial due to ethanol maybe bot exactly sure especially since it's a plastic tank
05-28-2011 11:35 AM
Jerry Bransford How did you get so much debris in your fuel tank?
05-27-2011 09:29 PM
jmpierce Even hit a little mud
05-27-2011 09:19 PM
jmpierce Got my tank back on and my jeep back runnin
05-26-2011 03:39 PM
jmpierce What's this part even called that goes on the end of the hose
05-26-2011 02:09 PM
jmpierce Can you replace the adapter the clip goes in that's attached to the line
05-26-2011 01:36 PM
blever You will either need to replace the clips that lock the line to the fuel pump module or the fuel lines. If you don't have those clips the fuel pressure will bloe the fuel line off.
05-26-2011 01:23 PM
jmpierce got new fuel pump strainer
05-26-2011 01:22 PM
Peepers Holy crap did you have some junk in your tank.

as to having to replace the end... No idea...
05-26-2011 01:17 PM
jmpierce Got new fuel pump drainage on tank and fuel pump fuel filter cleaned and back together ready to strap it back on. I just need to know if the end piece of the hoses going to the tank needs to be replaced since I broke the clips to lock them they seem to go on tight and still hard to get off
05-25-2011 08:43 PM
jmpierce The sock
05-25-2011 04:56 PM
jmpierce Some I filtered most is the larger stayed in the tank
05-25-2011 01:03 PM
jmpierce Ya there was a clip but they wouldn't come out on two and I had to brake the clip
05-25-2011 09:03 AM
Peepers I believe there should be a clip that stays on the fuel line / pressure regulator, and that line pulgs into each end and the clip holds it in place.
05-25-2011 08:57 AM
jmpierce Ya it is pretty bad but I went to order the sock and it showed two you can order I don't know how it was running as good as it was. Ya the fuel line that's what I was talking about I actuallly broke two the clip would come out one side and get stuck ended up braking the little clip
05-25-2011 08:46 AM
Peepers The only filter after the sock is the "permanent" (Stupid jeep) filter in the fuel pump. If your tank is as bad as you say it is I would replace the whole fuel pump assembly just to be on the safe side.

Gas Tank Sending Unit by Chrysler and Other Jeep Parts and Jeep Accessories by 4 Wheel Drive Hardware

are you talking about the line that goes from the fuel pressure regulator to the hard line on the frame? That is a very annoying line to replace because it is two different sizes. If I remember right it is 5/16 on one side and 3/8 on the other end.

I had that line leaking down the inside of the clip, both the stock on and the one I bought to replace it. I ended up taking a piece of 5/16" ID fuel line and streching it over both connections and using two hose clamps on each end, one on each side of the nipple. It hasnt leaked yet for me.
05-25-2011 08:32 AM
Fuel problems

Well got tired of my jeep dying so I dropped the tank. Tank was full of trash, sock was nearly totally clogged inside of sock and solid. Is there another sock on there somewhere by the way? And the plastic clip that connects the fuel lines to the tank I broke can I just cut them off and use tie straps to hold them on?

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

All times are GMT -5. The time now is 09:44 AM.

Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC. is not in any way associated with the Chrysler Motors LLC