Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ General Discussion Forum > Bad spot on frame

Join Wrangler Forum Today


Thread: Bad spot on frame Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
03-28-2012 11:30 PM
Richlw3 Doing a frame swap is a big project. Take a look at what I did to buy my jeep a few more miles of life. You might want to consider doing the same. PS this jeep frame has over 230,000 miles on it.
12-28-2011 08:58 AM
jasonduke5 Ya i hate to think the jeep is junk now. It only has 90,000 miles on it. I found a used frame for 450 bucks. I am going to look at it. It might have the same problems. But if it is nice i will spend a weekend and switch everything over. That is a ton of work.
12-28-2011 08:47 AM
Moose-Island My experience with a previous vehicle - no one would touch the frame repair because of liability issues.
My vehicle ended up being bought by a welder.
12-28-2011 08:38 AM
jasonduke5 I googled it to see what i could find last night and this is what i found on youtube. It is the same problem i have with my jeep but not as bad. I went to one local shop and they said they wont touch it. i am looking around for another shop. here is the youtube link
JEEP WRANGLER FRAME REPAIR TRAILING ARM 1 of 9 - YouTube
12-28-2011 07:06 AM
wwch99tj It doesn't look like it extends far enough up toward the rear spring perch. Look for a shop around you, you can probably get the repair done for the cost of that patch panel
12-28-2011 06:36 AM
jasonduke5 Ok so i cant find any other spot on the frame that is bad at all. I Found these online but dont know if they are worth it or not. I dont know the P.A frame laws about welding stuff to the frame. What do ya think.
Rear Trailing Arm Mounts Frame Repair - Left Side (ART-124-L) [ART-124-L] - $179.95 : Safe-T-Cap Frame Repair Kits by Auto Rust Technicians, we make it easy to make it safe
12-24-2011 01:40 PM
wwch99tj I would check the whole frame over really good. That is a common place on the TJ's frame for rot
12-24-2011 01:04 PM
jasonduke5 ok thanks. i was just worried that i didnt see this spot until now and just hoping there isnt any more like this. Thanks for the info
12-24-2011 01:02 PM
wwch99tj If that is the only spot that is bad you could cut out and replace that section for cheaper than replacing the whole frame. Check out a shop that does collision repair might be cheaper than you think
12-24-2011 12:52 PM
jasonduke5
Bad spot on frame

i was under my jeep today and noticed some rust on the frame that i had not seen before. before i go the jeep i went over it very well and didn't see this before. it just looked like a little surface rust. but as i cleaned it kept getting bigger and bigger. I got out as much as i could and put some rustoleum paint on it so it doesn't get any worst. No the issue is what do i need to do to get this fixed. this is the only bad spot on the frame that i could find. I found a whole frame in really good shape about 300 miles away for 650 bucks. is that the route i should go or should i take this to a shop and have it fixed. Is that possible?

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 07:22 AM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC