|04-25-2008 02:01 PM|
|Brewski||check out the thread under this one|
|04-25-2008 01:00 PM|
|jpoutlaw||It's a nut -- and a Jeep. They are suppose to be scruffed up.|
|04-24-2008 10:35 PM|
|04-24-2008 10:00 PM|
|PHAZE||How do you get those nuts off without making a mess out of them?|
|06-18-2007 10:11 PM|
"This is my first jeep and had someone said these magic words to me while I was looking for how to take the doors off it would have made it a while hell of a lot easier."
All you had to do was ask. :duh:
|06-18-2007 09:40 PM|
|RustyNBeatin2000||I used a jack and some 4x4's.. prolly wasnt the best.. but it popped them off quick lol!!|
|06-18-2007 02:44 PM|
|dj_chizzle||some sort of lube, patience, and moving the door back and forth. remove the door strap from the hook so you can swing your door all the way forward towards your front fender. swinging it out wide like that eventually did the trick for me. putting some sort of tape around the area will help avoid any little scratches too, or just be extra careful when you finally pull them completely out. you are prone to scratching too when you put them back on.|
|06-18-2007 12:38 PM|
Ok, I gotta say it. This is my first jeep and had someone said these magic words to me while I was looking for how to take the doors off it would have made it a while hell of a lot easier.
The hinge pins are fixed. They're attached to the door side of the hinge. This might not be your problem, but I know it was mine. Tex is right, just work the door back and forth while you lift it upward. They'll slide right out and if not, WD40 them.
|06-18-2007 12:35 PM|
|Dare2BSquare||For the first time you remove, I would put painter's tape around the pins and hinges, so that when it does release, you won't gouge your finish if you lose control while pulling up. Soaking overnight with WD40 or white lithium grease in a spray can will help.|
|06-18-2007 12:32 PM|
|Texapple||move the door back & forth while pulling up (use those muscles)|
|06-18-2007 11:29 AM|
|TJ_Babe||rubber hammer and WD-40? (my paint job wasn't the greatest to start with. lol)|
|06-18-2007 11:25 AM|
|Black and Tan 03||
Door Removal on 2003 Sahara
Any Trick to removing the Sahara Hard Doors for the first time ? I tried over the weekend, the nut was easy to remove the pin (bolt) would not budge. Any suggestions ?