Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ Tech Forum > really annoying front end noise

Join Wrangler Forum Today


Thread: really annoying front end noise Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
01-18-2009 09:37 PM
autogyver I seen a mounting kit some where that mounted the shifter to the transfer case instead of the body for lifted jeeps may have been Quadra or 4wd magazine.i'll try to find it later I was having the same problem but I replaced transmission and greased the fool out of the linkage and bushings and no more problem for now atleast 6 months ago, you might try some grease but they are tough to get to.
01-18-2009 09:21 PM
surfcape i really hope that it is just the bushings
01-18-2009 09:20 PM
surfcape no body lift but looking to have one installed soon. its only a half inch of play in the lever and i guess that the noise that i was hearing originated at the front axle or in the front drive shaft and then transfering through the case up to the lever where it was tapping and making the noise. i'm not sure about this but its my best guess. i was driving around and i slid my had down the shift lever and i could feel the transfer case vibrate and almost move a little bit as i was driving and as is shook, the lever was slowly rising about a inch higher than when i press it all the way down. if i press down on the lever as hard as i can in 2-hi there is no noise what so ever so does any one know what that could be? i have the full traction t-case lowering kit that came with my lift, and the shop said that they had to lower the front part an extra half an inch to get the clearance they needed, could this be causing the movement?
01-18-2009 04:39 PM
Jerry Bransford Is there a body lift installed? T-case shifter rattles are not uncommon when body lifts are installed but on newer TJs, I think there might even be a TSB (tech service bulletin) for a noisy t-case shifter linkage. Not sure if your dealer would do it for free if your Jeep is still under warranty due to all the mods you have installed.
01-18-2009 04:36 PM
jdhallissey lots and lots of rubber! Really tho probably just new bushings. IF they are new then try to find a delrin bushing or plate that you can bolt to the side so it can not move.
01-18-2009 04:33 PM
surfcape well just figured out where the noise is coming from so i'm not completely crazy. there is about a half an inch of play in the lever for my transfer case and when i shake it side to side it makes the tapping noise that has been plaguing me since i lifted the jeep. The t-case lever in 2-hi never has never gone completely down, you can push the lever all the way till it stops but after driving ten feet it has shaken its way a half an inch higher. the jeep shifts into 4-hi and 4-low fine, but how would i stop the play in my t-case lever or do you think that the play in in the t-case, or in the t-case linkage? where should i begin to look to try to stop the tapping
01-16-2009 07:36 PM
surfcape i was wondering if the noise could be from the bar pin's because the noise is almost a thunking noise
01-16-2009 06:32 PM
surfcape no play in u joints at least with my vehicle on the ground and the thing with the tapping almost creaking noise was that i heard it while i had the jeep in park and ball joints were done about 8 thousand miles ago. its this weird noise that i cant describe and i know that its impossible to diagnosis a noise from the internet but it really sound like it is in my joints in the steering column, the linkages in them because when i grab the rods and shake them there is some play and the noise is a similar knocking or tapping. my quick disco's are the factory ones that came with the full traction lift and have lots of play but the noise is still there when they are disconnected
01-16-2009 04:27 PM
4point Look at your axle and drive line U-joints.
01-16-2009 04:11 PM
surfcape sorry, bushings.
01-16-2009 12:36 PM
lap49X Tranny mount? Motor mount?
01-16-2009 07:47 AM
surfcape
really annoying front end noise

i have had a annoying thunking or tapping noise coming from the front drivers side when i pull into a parking spot. it gets even worse when i back out with my tires turned towards the drivers side. First i only heard the noise when i was moving but last night i was sitting still with the vehicle in four wheel drive and it started making the tapping noise under the front of the dash. i'm not sure if it could be worn out transfer case or tranny mounts, my next guess is that it is coming from the steering shaft but that seems unlikely. the tires are not rubbing or anything simple like that. but when i pull into a parking spot it sounds like the front axle is going to fall off. then when i turn the key off it makes a thunk or two as the engine shuts off. any info on possible places to investigate would be great, thanks.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 02:58 PM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC