Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > CJ Jeep Forum > CJ General Discussion Forum > Cj not running good

Join Wrangler Forum Today


Thread: Cj not running good Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
03-18-2013 01:19 PM
Goofyjumper A good trick I use to blow out fuel lines to use my air compressor (regulated to low pressure like 25 psi) and connect to the fuel line going from the pump to the tank. The pump (located on the timing chain cover) will have a line going up to the carb and another to the tank. Disconnect the line headed to the tank and attached the air compressor line to this. Warning: Do this outside and ground the airline to the vehicle to prevent sparks. Also open the fuel filler lid to allow pressure to be relieved from the tank.

If this doesn't work then your fuel pump may be gummed up by old fuel. Easy fix for this is to remove the fuel pump from the engine (two bolts) and spray carb cleaner in it. Then manually work the pump to loosen it up.

When you put the fuel system back together it will need to be primed to function correctly.

Good luck!
03-18-2013 11:41 AM
NHflannelman12JK76CJ5
Quote:
Originally Posted by ksjeeper View Post
Ya I was pretty happy about it. I think the pump has been going to awhile now cause its running better than it has for a long time.
I may have run into the same issue with my 76 this past weekend. Previous owner said she's been sitting 5/6 months. It's the 304 with Mototcraft carb.

I got in and tried to start her up, she was free but not turning over. Cracked the hood (spark plugs were OKAY, but need to be replaced), new battery, air filter was fine/clean.

Sprayed some started fluid down the carb, got her to fire up briefly. Looked at the carb - a bit milky looking where the intake line is (my guess is there's some water in there and the carb needs a rebuild). However, when inspecting the line, it was dry - followed it back to the fuel filter and there wasn't much of anything in there.

Now, this is where I need help (more than usual) I followed it back to the fuel pump - cam mounted? but I can't find the fuel line that feeds the pump.

So I tried to follow it back from the tank - looks like it rides the frame-rail for awhile but then I lose it under the drivers side door (near the break-lines I believe). After that I proceeded to, literally, bash my head off an old plow mount and then hit the back of my head off the concrete. I know - you're jealous of my klutz-induced concussion.

I'm not 100% dumb but could use a diagram (do have the Haynes, but not finding much help there). Does anyone have one? Or could anyone guide me through it?

I know I can replace the fuel pump (not that expensive of a pump) but I'm worried that the fuel line is clogged somewhere so I'd like to clear the lines out.

Thanks,

Trav
03-04-2013 10:33 AM
ksjeeper Ya I was pretty happy about it. I think the pump has been going to awhile now cause its running better than it has for a long time.
03-04-2013 08:50 AM
bc3_Jeep
Quote:
Originally Posted by ksjeeper View Post
Well I found the problem. Checked the filter and that didn't stop it ended up replacing the fuel pump and she runs like a top again.

Thank you for the feedback..... always good to get the answer at the bottom of a problem.
03-04-2013 08:33 AM
cwyatt6 Why
03-03-2013 06:25 PM
ksjeeper Well I found the problem. Checked the filter and that didn't stop it ended up replacing the fuel pump and she runs like a top again.
03-03-2013 01:01 PM
4Jeepn My did that.. vacuume line issues as i recall.. amazing what one messed of line will do to that system. My would idle fine but at speed would want to cut out and die.
03-03-2013 09:31 AM
ksjeeper Ya I hold it open for a little while and it never sputters or backfires. I will replace the fuel filter and see if that works. Thanks for the advice. I will let ya know what I find out
03-03-2013 09:26 AM
luv2bmx22 If it runs fine while reving it up a little and holding it there while stopped, it shouldn't be the fuel pump, because the motor is pumping the same amount of fuel in as if you were driving. Try using different gears if its a manual and see if it still does that.
03-03-2013 09:17 AM
bc3_Jeep How long are you holding the throttle open???? If it is a fuel pump issue, it should probably show up moving or NOT moving....

Hold it open for a bit (as long as it takes you to get to 25MPH)....... running a safe RPM..... and see if it sputters......

Also..... check the fuel filter.......easy and cheap.....
03-03-2013 08:42 AM
ksjeeper No it doesn't do it at all when it's sitting. I can open the throttle up and it won't do it. Just when I'm driving down the road. I was thinking maybe a fuel pump?
03-03-2013 06:30 AM
bc3_Jeep Does it also start this issue when it is sitting still but you crack the throttle open????

Sounds like it is starving for fuel to me.

Might also check to make sure yor vacuumn advance is working properly.

As always, check to make sure all of your ignition parts (plugs, wires, D cap, rotor) are in good working order with no carbon tracking. I am still leaning towards a fuel issue.
03-03-2013 04:33 AM
NHflannelman12JK76CJ5 others will know much better than I - but have you checked the distributor cap? I think that's the first place I'd look. Make sure the firing order is the way it should be.
03-02-2013 06:06 PM
ksjeeper
Cj not running good

Ok so my jeep is not running good at all. It will idle just fine and will run alright until it gets to about 25mph. When it hits that it starts backfiring and cutting out. When I slow down to 20 it runs fine again. I have no idea what is wrong with it. Any ideas??

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 02:16 PM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC