|03-31-2013 08:20 PM|
|03-31-2013 07:57 PM|
Thanks a lot I will try to do my best on this task. I will measure the joist before it gets too hot. once again thanks.
|03-30-2013 07:36 AM|
|wwch99tj||The ceiling joist are either 16" or 24" on center... so you'll have to find one and measure over from it... (mine are 16" oc and my eye hooks are 64" apart...)|
|03-29-2013 09:52 PM|
This is a great idea as well as inexpensive, I'm tired of asking friends over to help me take off the hardtop, now with your idea makes me want to go right at it! I have to see first where the studs are at because I have a flat roof garage. How far apart did you put the i-bolts? What length are the straps?
Thanks for any information that you can give me.
|03-09-2013 04:41 PM|
Straps did great. $20 SAMS
|03-06-2013 10:57 AM|
|Banditt135||Great Thread for us Newbs. Im getting ready to figure out a hoist system for my 2 door hard top on my Jk. I hate to go buy one when it looks so easy to build.|
|02-03-2013 03:35 PM|
|JeepReaper09||Very helpful Thread all, Im definitely going to do the ratchet strap rig this spring.|
|01-30-2013 03:16 PM|
I did the ratchet strap thing for a few years in my previous house's low ceiling carport.
Inexpensive and worked great.
I bought the Lange Hoist a Top when we bought our current house a few years ago. The garage has a fairly high ceiling and the straps would be difficult.
The only drawback is that the T-Bar lift is supported by one center point. This allows the top to swing around freely while suspended in the air. No problemo, I have some extra ratchet straps that I secure the top with while in storage.
I used the included come-a-long. I would love an electric hoist, but I could not justify the added cost. I've only put the hard top on once in the last 3 years!
|01-30-2013 07:04 AM|
|01-29-2013 11:06 AM|
|Generalkell||i have a question.. have you noticed using the hooks from the ratchet straps is putting stress on the jeep hardtop or ruining the rubber seal? im very interested in putting this up in my garage for my wife and I and we would store the top long term in the summer hanging from our ceiling most likely. Great video!|
|01-26-2013 01:52 PM|
|01-26-2013 11:42 AM|
|01-26-2013 11:03 AM|
|gwhar47||Hey folks, I just bought a '04 LJ with hard top, and need to rig something up to take it off (and put back on). Unfortunately, I don't have a carport or garage, so will have to figure something out for outside. I looked at Harbor Freight's portable hoist, but am concerned about lifting the top using only one point of lift. Any suggestions? Thanks.|
|01-25-2013 03:24 PM|
cool setup DEXTREME.
i see you covered your t-bar with foam pipe insulation, I did the exact same thing.
|01-25-2013 01:50 PM|
|chemicaljeep||d-rings in ceiling joist of garage and sturdy rope . drive under unbolt pull up tie off drive out. can still park in garage. when you put top back on back in let ropes down bolt down dive out. simple!!!|
|01-25-2013 01:48 PM|
|01-25-2013 01:37 PM|
Here is a few more pics of my set up:
HF Winch with a socket ready for my drill
The rack itself I made out of scrap metal I had left over from replacing a garage door opener track. I welded some scrap chain on it to add some weight for it to lower easy, and it gives me options for balance points.
Basically I lower it down on the hard top, hook up 3 ratchet tiedowns. Lift it off with the drill to the ceiling
Oh and those ladder hooks in the beam is where I hang my full doors.
|01-25-2013 06:27 AM|
DEXTREME i really like that geared winch, much better than the ratchet winch you get with the Hoist-a-Top system.
If I was removing/installing my hardtop on a frequent basis I would say get a device like DEXTREME is showing as the ratchet winch is sort of a pain and if you are not careful it can disengage allowing the top to free-fall. I remove my hardtop once/year so I'll deal with the slow ratchet.
|01-25-2013 02:17 AM|
|01-24-2013 09:12 PM|
|01-24-2013 09:04 PM|
Hand winch from harbor freight, some pulleys, rope, eye hooks and the hardtop dolly I used previously.($60-70)
|01-24-2013 08:35 PM|
|Mom sold the Jeepster||
|01-24-2013 08:09 PM|
Got my LJ top off with just me and my 5'4" -100lb wife. Wasn't too heavy, just awkard. Have since installed a Harken hoist, so putting it back on is a breeze. Here's a link, though they can be bought elsewhere for less...
|01-24-2013 03:27 PM|
|Brekk98||4 rachet straps and 4 i-bolts in the garage ceiling works really well for my hardtop.|
|01-24-2013 02:12 PM|
|01-24-2013 01:51 PM|
|Arch||How heavy would a 2 Door hard top be? I don't have a garage atm and was hoping to just get in the back and transfer it over to a platform of some sorts this summer.|
|01-24-2013 01:38 PM|
|01-24-2013 11:56 AM|
I use this winch mounted on the wall and a few ceiling mounted pullys to lift of my hard top. But the gearing on the winch is super slow to crank by hand, so I use a electric hand drill and a 3/4" (i think) socket instead of the handle...works perfect.
2000 Lb. Capacity Geared Winch
|01-24-2013 11:27 AM|
i bought mine last July, paid $119.99 plus shipping.
did price go up? even at $159 it is still a good investment for a useful tool.
|01-24-2013 11:24 AM|
|Cdubu52||Sorry mine was $150. Typo and no proof reading.|
|This thread has more than 30 replies. Click here to review the whole thread.|