Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ General Discussion Forum > Best engine upgrade help?

Join Wrangler Forum Today


Thread: Best engine upgrade help? Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
07-15-2013 08:06 PM
Christian6892 I'm new to this site and been trying to figure out what would be better to add new my 2013 JK sport. A turbo? Or a supercharger? I've researched RIPP for superchargers and STS and PRODIGY PERFORMANCE for turbos
05-02-2013 01:25 PM
mudmagnet63 Yes regear. I followed their advise and am stoked about the results. Plenty of power to run down the road at 70+ if I choose and even better on the trails.

Mud
05-02-2013 12:47 PM
MFsoftball22
Quote:
Originally Posted by UnlimitedLJ04 View Post
regear to 4.88s & install the correct speedo gear. problem solved.
X2 on regear
05-02-2013 10:35 AM
UnlimitedLJ04
Quote:
Originally Posted by ssgmiller558 View Post
Thanks for all the reply’s! Sounds like the first thing I’m going to do is figure out how to do the 4.88 gearing for those 35" tires
simple: take it to a drivetrain shop and have them install 4.88s gears. should cost between $1200-1800 depending on your area & the parts used.
05-02-2013 10:34 AM
Jerry Bransford
Quote:
Originally Posted by binnsmark View Post
Your best bet is a regear. Go to 4.56's... Or 4.88's if you plan on going bigger than 35 inch tires. You can buy chips and cold air intakes all you want... But the fact of the matter is you're trying to drive an underpowered brick at 70mph against the wind. If i were you... I'd get a regear and get some lockers put in while you're at it. You'll save money as they'll have everything taken apart regardless. No sense paying for the same work twice.

I have an 06 TJ with 35's and 4.10's. 6th gear is okay on the highway... But it's not as deep as your NV3550 in top gear.
4.56 would be fine with the 6-speed transmission you have and 35" tires but the OP has a 5-speed where 4.88 is the optimal ratio for 35" tires. 4.56 isn't quite enough gear for 35" tires & the 5-speed combination.
05-02-2013 10:34 AM
ssgmiller558 Thanks for all the reply’s! Sounds like the first thing I’m going to do is figure out how to do the 4.88 gearing for those 35" tires
05-02-2013 10:30 AM
ssgmiller558
Quote:
Originally Posted by sduncan View Post
start by doing a google search. If you had a harley then you know that there is an endless amount of $$ that can be spent. Jeeps are no different and probably even worse depending on how far you want to go....gears, axles, tires, v8 conversions, etc.
Give us some info on the current specs of your tj and that will give a starting point...tire size, gear ratio, trans type, what your intended uses are going to be ect.

If you want to drop some fairly serious $$ on a motor conversion for instance,then as a suggestion, read thru my build thats in my signature. I absolutely have no issues maintaining any speed i want..but it aint cheap...:d
wow that's awesome!!!
05-02-2013 10:30 AM
binnsmark Your best bet is a regear. Go to 4.56's... Or 4.88's if you plan on going bigger than 35 inch tires. You can buy chips and cold air intakes all you want... But the fact of the matter is you're trying to drive an underpowered brick at 70mph against the wind. If i were you... I'd get a regear and get some lockers put in while you're at it. You'll save money as they'll have everything taken apart regardless. No sense paying for the same work twice.

I have an 06 TJ with 35's and 4.10's. 6th gear is okay on the highway... But it's not as deep as your NV3550 in top gear.
05-02-2013 10:27 AM
Jerry Bransford
Quote:
Originally Posted by ssgmiller558 View Post
35" tires and 3.73 I believe, still learning about this Jeep, everything was already done to it when I bought it. Has lift kit, 35" tires, and a bunch of other stuff. Its a manual transmission. Lots of low end power but trying to drive down the highway in 5th gear (especially against the wind) drives me crazy. Seems I have to hold the pedal all the way down to the floor and/or downshift.
The 35" tire/3.73 axle ratio combination is the sole reason for your lack of power. There is nothing you can do to the engine to fix the type of loss of power that combination causes.

The way to restore the engine power & allow you to maintain speed even on steep grades is to regear your axles which will bring the RPMs back up to where they were when the Jeep left the factory. That is done by replacing the ring & pinion gears in both of your axles with a lower ratio replacements which will bring the engine RPMs back up to where they should be. The larger tires have reduced the engine RPMs at highway speeds so much that the engine can't develop as much power.

If your transmission is the 5-speed, 4.88 is the optimal ratio for a 35" tire. Once I regeared my previous TJ to 4.88 for its 35" tires, it was a pleasure to drive again. The cost of regearing both axles (both must be done) including all parts & labor is typically $1300-1500 depending on the shop.
05-02-2013 10:26 AM
freeskier Your issue is that 3.73 gear ratio. Re gear to 4.88 and it won't be an issue.
05-02-2013 10:25 AM
UnlimitedLJ04
Quote:
Originally Posted by ssgmiller558 View Post
35" tires and 3.73 ...35" tires...manual transmission.
regear to 4.88s & install the correct speedo gear. problem solved.
05-02-2013 10:23 AM
sduncan Start by doing a google search. If you had a Harley then you know that there is an endless amount of $$ that can be spent. Jeeps are no different and probably even worse depending on how far you want to go....gears, axles, tires, V8 conversions, etc.
Give us some info on the current specs of your TJ and that will give a starting point...tire size, gear ratio, trans type, what your intended uses are going to be ect.

If you want to drop some fairly serious $$ on a motor conversion for instance,then as a suggestion, read thru my build thats in my signature. I absolutely have no issues maintaining any speed I want..but it aint cheap...
05-02-2013 10:22 AM
ssgmiller558 35" tires and 3.73 I believe, still learning about this Jeep, everything was already done to it when I bought it. Has lift kit, 35" tires, and a bunch of other stuff. Its a manual transmission. Lots of low end power but trying to drive down the highway in 5th gear (especially against the wind) drives me crazy. Seems I have to hold the pedal all the way down to the floor and/or downshift.
05-02-2013 10:18 AM
freeskier Do you have larger than stock tires? What is your gear ratio?
05-02-2013 10:15 AM
ssgmiller558
Best engine upgrade help?

I am new to Jeeps and trying to learn as much as I can. I recently purchased a 2001 Sahara and having gone from riding a Harley for fun to a Jeep (a different kind of fun) I miss the ability to maintain a decent highway speed. It seems this 4.0 has a very difficult time maintaining highway speeds without having to shift down to gain power. Is there something I can do like add a supercharger, a turbo or install a larger engine without getting into too much of a hassle? Any help would be greatly appreciated.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 07:55 AM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC