Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ Tech Forum > Help removing hard top

Join Wrangler Forum Today


Thread: Help removing hard top Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
07-16-2013 04:32 PM
WredTJ Celebrate! Drive around topless!!
07-16-2013 03:02 PM
JeepGuy425 Thanks to Ricky @ Jeepers Den, I was able to get it off. There was heavy duty 2-sided tape in there, and he had some plastic pry bars to help loosen it up. It took a little bit but it's finally off. Thank God it wasn't silicon.
07-13-2013 01:30 PM
workshop4ever I was able to run two ratchet-straps under the top, and then used an engine hoist to pull up until it came loose. I ran the straps in the back window, and out where the door closes against the top. Didn't take much with the hoist, but like you...I couldn't get it off with just my back.
07-13-2013 01:09 PM
JeepGuy425 Another good idea, thanks Mark.
07-13-2013 12:55 PM
MarkGLHS sounds like the rubber gasket has fused the top to the body......i'd use a wire, pulled tight between the outside and inside (this is a two-person job), run it along the bottom of the top....that will break the seal and not damage either the top or the body.
07-13-2013 12:35 PM
JeepGuy425 Wow... I never considered the previous owner might have done something like that. The plastic putty knife idea was a good suggestion, going to give it a shot.
07-13-2013 12:28 PM
Dextreme
Quote:
Originally Posted by Jerry Bransford View Post
Let's hope the previous owner didn't consider that top 'permanent' and sealed it with silicone.
That is what I was thinking..or even something worse like epoxy or polyurthane glue. I would maybe use a plastic putty knife (from the inside) and work it around between the tub and top.
07-13-2013 12:19 PM
Jerry Bransford Let's hope the previous owner didn't consider that top 'permanent' and sealed it with silicone.
07-13-2013 11:58 AM
wwch99tj You're going to have to get something in between the top and the tub to pry gasket up to break its seal to the tub

Man that looks really clean, nice find!
07-13-2013 11:52 AM
JeepGuy425
Help removing hard top

I just picked up a 02 TJ at a local dealership. It was a good find, 1 owner, retired, garage kept, 110k highway miles, never had the hard top off, pristine condition.

I've removed a couple hard tops before, but this one is STUCK. Never have I removed a hard top with a rear defroster though. Unlocked the front brackets up by the windshield, unscrewed 3 bolts on each side in the back, and unclipped the electric wire. I don't see anything else holding this sucker down.

I got inside the back, put my back up against the roof, and pushed harder than a chick in labor. Nothing. I gave the front portion of the roof a few good bangs with my palm, this thing isn't budging. I'm thinking that maybe 11 years baking in the sun the seals between the top/body have melted and its on there pretty good.

Any ideas on how to remove it without doing any permanent damage? Attached some pictures. Maybe there is a clip or something I'm missing?

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 06:44 PM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC