|07-29-2013 11:07 PM|
I would have expected to see some draw though if there were an obvious drain.... and there really was none on my ammeter once I turned key off and removed from ignition. Its not a Fluke, but a decent craftsman. so that's why I am wondering if it might have been the mercury switch that 'sometimes' might get stuck on, but not always. I took the whole unit out just in case.
|07-29-2013 08:27 PM|
|R u s s|
|07-29-2013 07:45 PM|
Inductive clamp is even better. Verify that it'll read DC, set to the lowest resolution and zeroize. The example I'm using is a Fluke 36. Verify that you have it set-up right by observing the display and then energize some circuits like headlights, horn, whatever. Power the jeep key on engine off, then key off and observe the keep alive memory draw.
There's a possibility you have a weak battery. In that case, load test to 50% of the CCA and observe the VOLTAGE drop for 10 seconds. Note the air temp; at 70f the drop should not be lower than 9.7v plus/minus. If lower, fail.
Don't blow-off a dirty wet battery essentially shorting itself! Happens!
|07-29-2013 06:59 PM|
what diodes fail, and how could I test?
I have a clamp-on ammeter, and did not measure any current from battery after I turned everything off today.... no real clue what may have drained the battery last week.
|07-29-2013 05:47 PM|
Dirt on the top of the battery can create a parasitic draw if it is moist and touches both posts.
Parasitic amperage draws can be checked using a digital volt ohm meter connected in series with the battery and ground. The keep alive memory of the PCM and other users such as the radio can be expected to be 0.1-0.2a. CB's, etc., can draw up to 1 amp powered, which will draw the battery down overnight depending on its state of charge. Brake lights on, alternator field current, underhood light, etc. can draw the battery down too. Do the test above, and remove fuses or disconnect accessories one at a time to isolate circuits.
|07-29-2013 05:22 PM|
There is a mercury switch as part of the hood light (some models), but the switch itself shouldn't drain the battery Unless the light is on (bulb is good).
There should be an off(unlocked) position next to the off(locked) position on the ignition switch. You may have left it in the next (on) position. On many you can remove the key in any position after the lock is worn. What year is the Jeep?
|07-29-2013 05:04 PM|
alternator appears good.... battery sitting at 12.8v, up to 13.8 when started and idling.
poked around some, and found suspicious light/switch under hood.... appears to be some kind of mercury switch designed to slide and come on when hood is opened. Is that what this thing is?, and does it perhaps commonly get stuck 'on'?
Other thing is that I realize I left the key in the ignition.... clock was on, and when I removed key today, clock display went off..... would other stuff maybe stay on 'enough' to drain battery over a week if key was in ignition?
|07-29-2013 02:13 AM|
|R u s s||Also look at any thing after market installed. I find 90% of problems come from mods. But also try unhooking the alternator wires when you park it some time the diodes fail where it charges but after you shut it down it drains the battery|
|07-27-2013 08:48 PM|
|Water Dog||If there are no doors on it, the courtesy lights and/or dome light could have remained on. If that's the case, pull fuse #4 in the fusebox behind the glove box (It's the door switch defeat fuse.)|
|07-27-2013 08:10 PM|
common shorts draining battery?
I'm new to TJs.... cleaning up a friend's to sell. It was sitting for 18 months, battery was dead as a doornail, so I put in a new one. Started right up. Drove 6 miles to my garage, installed new soft top, week later tried to start.... nothin!
so, either dead alternator or a short/drain somewhere.... since it was ok when I parked it, I'm suspecting a short or a light or something perhaps common to TJ that might drain a battery over about a week?
I have a battery charger on it now, and will get alternator tested, but hard to take it in because its not registered at the moment....