Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > YJ Jeep Wrangler Forum > YJ Tech Forum > no power to fuel pump

Join Wrangler Forum Today


Thread: no power to fuel pump Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
08-14-2009 10:54 PM
minderbinder3 All's good. I replaced the fuel pump today and she fired right up. It wasn't too bad I bought the pump from Autozone for $81.99, as well as a new strainer for $11.99. I could not see anything visibly wrong with the other one but something apparantly went bad. Getting the tank down and out and then in and up was a bit of a struggle, but after I cut the rusty bolts off the skid plate it only took me a couple of hours. My tank is poly and surprizingly clean on the inside and I cleaned up the connectors on the sending unit while I was there. She idles better now...however my fuel gauge no longer works. Any ideas? By the way...thanks for all your help on this one. It feels good to have her back on the road.
08-13-2009 03:34 PM
minderbinder3 Autozone has each (screw on and snap on) of the fuel pumps in stock for under $90, so I'm going to pull it and then see which one I need. I am also going to replace my filler tube while I'm there because mine has some cracking. I had to order it from the dealership but it was only $20. Thanks for your help and I will post my results.
08-13-2009 12:22 PM
skeeter fuel pump at shucks auto
08-13-2009 09:57 AM
whitebuffalo i just went through this. jeep was running fine one minute and then died and wouldnt restart unless i gave it some ether. on mine, the prefilter/sock/strainer thing that is on the end of the fuel pump basically imploded and went into the fuel pump. the pump is around $140 iirc.
08-13-2009 08:04 AM
minderbinder3 You were right. Once I test the connector while someone turns the key...I get a flash of power similar to the other Jeep's. I have checked all fuses and relays and they seem fine. The reason I am wondering if it really is the fuel pump or not is because it did not give any warning when it stalled. It did not act like it was fighting for fuel or anything, but either way there is no fuel at the TB.
08-12-2009 11:35 PM
skeeter You'll only have power to the fuel pump for a second or so when you hit the key.
Have someone else turn the key while you watch the tester.
Also, make sure you're testing the right wire, it's really frustrating to spend a bunch of time looking for an electrical problem only to find out you were testing the gauge wire
08-12-2009 11:33 PM
wbrett1027 try fuses or reley
08-12-2009 11:17 PM
minderbinder3 You talking about 1 of the three wires that run to the connector for the fuel pump or is there another ground somewhere?
08-12-2009 10:49 PM
Captaincoop1220 the same thing happened to me a few years back, it turned out to be a bad ground wire. i ended up cutting it and running a new ground. good luck
08-12-2009 10:26 PM
minderbinder3
no power to fuel pump

My 1991 YJ 2.5 suddenly died yesterday. It has spark, but no fuel pressure and the fuel pump doesn't come on at all. I checked the voltage to the fuel pump it doesn't have any. I checked another similar Jeep it had 7+ volts going to the fuel pump. I checked and changed all the relays and still nothing. It has power going into the power box (where the relays are) and I cleaned all the terminals and grounds I could find on the firewall just above the power box and battery. Any suggestions?

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 04:33 AM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC