Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ Tech Forum > 97 TJ 4cyl cold idle/running issue

Join Wrangler Forum Today


Thread: 97 TJ 4cyl cold idle/running issue Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
06-26-2010 07:21 AM
lambdatoys
Quote:
Originally Posted by shipjim View Post
I followed Jerry B's advice and sprayed the airintake for the throttle body with throttle body cleaner. Having done all the electrical stuff, this worked for about 8 bucks.

So far this worked best for me too, but it isn't 100% fixed. I actually removed the throttle body, removed the sensors, and thoroughly cleaned everything with carb cleaner. That helped with the rough idle and every-once-in-a-while hesitation.
06-25-2010 10:04 PM
shipjim I followed Jerry B's advice and sprayed the airintake for the throttle body with throttle body cleaner. Having done all the electrical stuff, this worked for about 8 bucks.
06-23-2010 04:20 PM
lambdatoys
Quote:
Originally Posted by sthomp View Post
I had the exact same problem on my 99 tj 2.5L and after some research on several forums I figured out it was the upstream O2 sensor. Apparently the heater circuit will go bad and tell the engine that it is warmed up prematurely and causes random sputtering until the engine gets up to temperature. You can test it by disconnecting the upstream O2 sensor plug and see if the problem goes away. I found an O2 sensor on ebay for 20 bucks or so, problem solved! Good luck!
No check engine light? I thought about the various sensors but thought if they were bad the check engine light would come on.

Thanks for the info, I'll try it anyway in a few weeks and let you know!
06-23-2010 04:03 PM
dkswift Thanks sthomp.
06-23-2010 01:06 PM
ruprect Glad I'm not the only one that had this problem. I'll try O2 and see if it works right after I find out why the damn thing won't turn over at all.

Thanks.
06-23-2010 08:57 AM
sthomp I had the exact same problem on my 99 tj 2.5L and after some research on several forums I figured out it was the upstream O2 sensor. Apparently the heater circuit will go bad and tell the engine that it is warmed up prematurely and causes random sputtering until the engine gets up to temperature. You can test it by disconnecting the upstream O2 sensor plug and see if the problem goes away. I found an O2 sensor on ebay for 20 bucks or so, problem solved! Good luck!
06-23-2010 05:05 AM
lambdatoys having the same problem on my 97 4cyl w/102k. So far new plugs, wires, rotor & cap, air filter, and 3 or 4 bottles of fuel injector cleaner and it still hasn't fixed the problem. Took the throttle body off and thoroughly cleaned the junk out of it, which helped with the rough idle, and may have reduced the sputtering, but it's still there once in an while. I was thinking next of trying a new mopar tps. Any other ideas?
06-22-2010 06:26 PM
flatline Wide open throttle is when a weak pump would show up, but, check fuel rail pressure. maybe dirty injectors. throtle positioning sensor. those would be my next steps.
06-22-2010 06:16 PM
dkswift Did all that. Plus a tank full of Lucas fuel treatment. Got 198k on the clock.

Am I wrong to assume that if it was a fuel pump or filter, it would run crappy all the time? Because the stutter only happens when I first start it up and take off. It is honestly about 30-50 seconds into it running, whether it is still idling in the driveway or leaving the house about halfway through 1st gear. It stutters something fierce, but running out the clutch or just pushing the clutch in a revving the motor a couple time gets it through. Once it does it once, she runs perfect.
06-22-2010 06:03 PM
flatline don't jump ahead, start with the basics. how long since the last tune-up? how many miles? the cap if you pull if off will have what looks like corrision on the contact points. new caps have either alluminium or brass contacts nice and shiney. Pull one plug and see how it looks, how old are the plug wires? you can check resistance to see if one or more are bad. air cleaner? thats a good start right there, then on to the harder stuff.
06-22-2010 05:45 PM
97'wrangler I looked and there's nothing there, the fuel filter is in the tank and should never need to be replaced. And how would how no if you need a new cap?
Could it be the map sensor?
06-22-2010 05:38 PM
flatline I usually start with cap rotor plugs before I go to fuel. are you sure there's not a fuel filter on the frame just foward of the rear drivers tire?
06-22-2010 05:09 PM
dkswift x2
06-22-2010 04:32 PM
97'wrangler I am having that same problem... Its not to much of a big deal for me, but if it is an easy fix i would not bother doing so. Any thoughts on what this might be!
06-22-2010 04:13 PM
ruprect
97 TJ 4cyl cold idle/running issue

Less of a jeep question, and more of an overal engine question. When my jeep sits cold for any length of time, 10 minutes or 10 hours, it cranks and idles fine. But when I give it gas, it sputters and wants to die. Once you rev it up a few times, it runs like a top.
I thought it might be a fuel filter, but found out on this thing you have to replace the whole fuel pump!!! Wow.
Any thoughts or suggestions?

Thanks,

Ruprect.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 02:07 AM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC