Jeep Wrangler Forum - Reply to Topic
Jeep Wrangler Forum

Go Back   Jeep Wrangler Forum > TJ Jeep Wrangler Forum > TJ Tech Forum > Weird water leak

Join Wrangler Forum Today


Thread: Weird water leak Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Jeep Wrangler Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
If you do not want to register, fill this field only and the name will be used as user name for your post.
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
07-23-2010 04:34 AM
Sticks If you have correctly identified the source of the leak, yes, a caulking tube of silicone RTV and careful application will cure your ills and create a flexible seal. The only place that may be a problem is the steering shaft, in which case you would need to get a rubber boot.

BTW, might want to wire tie up those loose wires under your dash/engine compartment.
07-22-2010 01:14 PM
CubbieBlue Not a clue? C'mon guys I need some help! (And a Jeep project for this weekend!)
07-22-2010 08:45 AM
CubbieBlue Bump for the mornign folks
07-21-2010 09:30 PM
CubbieBlue Well dude I think I found what it is. On the passenger side it is DEFINITELY that foam gasket where the heater and ac lines run through it. I just don't know how to fix it? Silicone around it? Build a little shelf over it? On the driver side it is the seal around that steering shaft and possibly some other seals that are not perfect.
07-21-2010 09:26 PM
IndyJeepMan Same leak, lots in the passenger side, a little in the driver side. Almost everytime it rains. I've just got to the point where I dont worry and just drive and let it leak out through the drain. I have no clue on what it is, its coming through the dash though..
07-21-2010 09:14 PM
CubbieBlue
Quote:
Originally Posted by IndyJeepMan View Post
Mine does it too, I dont worry about it because i have lining in the bottom and I took the plugs out with carpet though I would look into. I know its a common problem with Jeeps so someone has to have the fix, I just thought I'd let you know you arent alone
Leaking in general or the same type of leak I am experiencing?
07-21-2010 08:51 PM
IndyJeepMan Mine does it too, I dont worry about it because i have lining in the bottom and I took the plugs out with carpet though I would look into. I know its a common problem with Jeeps so someone has to have the fix, I just thought I'd let you know you arent alone
07-21-2010 08:50 PM
CubbieBlue n/t
07-21-2010 08:46 PM
CubbieBlue
Weird water leak

Leaking water in the front passenger AND driver side (less on the driver side)

Pulled the cowl and sealed that intake up that cause a lot of people problems, thought that would solve it. - Nope.

Pulled cowl again and checked that drain to see if it was clogged. - nope

I sat there and ran water all over/in the cowl area and my GF said no water was running in during that time. I even ran it full blast down/around the drain in the cowl thinking perhaps it a seal around the drain was the issue, nope (at least she says so).

I started to spray around the battery - YES. I read that there is some thing to seal behind the battery but there doesn't seem to be anything behind mine...

I sprayed this foam piece where the AC is tubed into it - leaking alot she said.

I then sprayed by the driver side and she said ti was leaking a little pretty much whereever I sprayed it. WTF?!

I go inside and see that there is water beading down from the steering shaft thing.

Here are pics:

How do I solve these leaks? I can run some sealant stuff around the steering shaft o-ring, but I don't know what to do about the other one.

I tore out the carpet and I think I am going to herculine it this weekend, I would still like to solve this problem however as I do not have a garage.

Thanks all.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 09:29 PM.



Jeep®, Wrangler, Liberty, Wagoneer, Cherokee, and Grand Cherokee are copyrighted and trademarked to Chrysler Motors LLC.
Wranglerforum.com is not in any way associated with the Chrysler Motors LLC