|01-13-2014 08:51 PM|
|tj04||mine does that when there is cold weather….Once the jeep is warm it stops|
|01-13-2014 12:30 PM|
|01-13-2014 03:41 AM|
|NH-JK||I just replaced my tentioner pully with one from autozone. It was about 12.00 bucks. There are two that pop up for the 1997 4.0, yours maybe different... One pulley is small the other is bigger in there system, you will need the bigger one. I bought both and matched them to the old tentioner pulley, it was the bigger one, which is cheaper!|
|01-12-2014 08:33 PM|
|01-12-2014 08:26 PM|
|01-12-2014 08:21 PM|
|Jaws1206||Tighten your slack adjuster. Should fix the problem.|
|01-12-2014 08:11 PM|
|Majnoon||You stick a 1/2 inch ratchet or breaker bar into the square on tension arm release pressure remove belt. Like dis.|
|01-12-2014 07:48 PM|
|curlysfries||Thanks all. Will check pulleys as soon as I figure out how to take belt off.|
|01-12-2014 09:32 AM|
|harryhood||Agree with those who say it sounds like an idler pulley. it's easy enough to check; pull the belt and remove the pulley, and spin the pulley on your finger. If the pulley does not spin smoothly it's bad.|
|01-11-2014 11:28 PM|
|Tys98tj||Mine had a similar noise. I hadnt cleaned my engine bay in forever so I sprayed the mud off of the fan and it went away|
|01-11-2014 07:40 PM|
|Tomreb77||Idler. And change your belt while your at it. Easy to do, couple hours for someone like me a newbie. Good luck.|
|01-11-2014 10:32 AM|
15 minute job and allies silent again. Once pulleys were off you could spin the old ones in your hand and feel as well as hear the grit in the old bearings.
I did have to go return the idler pulley and swap out for a Dorman unit as the first on would not seat properly.
|01-09-2014 11:37 PM|
|CTX-Ross||Did my water pump recently. Almost every pulley on the jeep is trashed... Idler, Tensioner, and A/C (water pump was about gone). They squeal and make the same noise. Idler is like $25 tops|
|01-09-2014 09:31 PM|
|01-09-2014 06:59 PM|
Just removed my belt to check my pulleys as I have a similar noise. Turn out I my tensioner pulley is noisey and has some play in it too. Guess what I am doing this weekend.
With 130k on the clock, it is due anyways the way I use my Jeep.
|01-09-2014 03:57 PM|
|Oldjeeper69||Sounds like your idler pulley.|
|01-09-2014 03:23 PM|
TJ "Squealing" Noise from front fan area - Video
I have a 2002 Jeep wrangler x 4.0 112K miles, manual. When I start my engine I get this odd noise which I call "squealing" from the front area near the fan. I can't tell where its coming from or whats causing it. Jeep runs fine otherwise and it happens mainly when its cold outside.
Any assistance of what this might be would be greatly appreciated. Ive included a small link with video of engine and noise.