|11-10-2014 10:00 PM|
|MnJK||Curiosity got the best of me. Checked my 2014 and found the same as Barmanvarn. No issues and running 33's.|
|11-10-2014 09:32 PM|
|11-10-2014 09:18 PM|
|11-10-2014 07:42 PM|
|NYJETS||I have a lift and extended brake lines so no issues but I would recommend getting a set of extended brake lines and relocate the brackets or run the lines behind the shock.|
|11-10-2014 06:39 PM|
|made in the USA||it will rust in 2 eventually that is what mine did i put some wheel spacers on and that took care of problem|
|11-10-2014 03:54 PM|
|funlovinggrrl||My Jeep is a 2008 - I did notice that the dealer had trimmed the interior fender shroud. I'm inclined to say that this was due to tire wear from left turns - passenger side doesn't show any sign of rubbing. Still have the same size tires that came with it, so tire size isn't the problem.|
|11-10-2014 02:01 PM|
I see my lines are routes different on my 2012 but have a lot of jeep friends. What years would be affected by this? Would like to pass on the info.
|11-10-2014 01:28 PM|
|NJJeep Guy||I had this same issue a few months ago when I replaced the wheels and tires. Jeep has replaced the part with a new line, but does not have a recall for the problem. No wear on the passenger side. Only the drivers side was rubbing through. Thankfully it was not fully cut like that pic above.|
|11-10-2014 01:02 PM|
Having the same problem
Went to take my daughter to school this morning, brake pedal went to the floor, said a few choice words, got out and found brake fluid leaking out.
It's bulging and worn thru.
Stuck waiting for my hubby to come home and help me get the freaking lug nuts off, stupid tire guy over torqued the damn things. Glad I was stuck in my driveway and not on the side of the road.
|03-25-2014 02:28 PM|
hmmm, while I was installing my rock sliders today I decided to take a look at this issue, and sure enough my tires are rubbing on the sleeves. Worst part is the right side was actually touching the line as it had come loose and got in between tire and sleeve
|03-25-2014 08:30 AM|
Tires don't appear to be bulging. At least not in any major way. This only occurs when turned full lock left.
|03-24-2014 11:57 PM|
|Douglas Wray||Is it just just my perception or do the side walls on the pictured tires appear to be bulging out against the brake line? Does he have the tire aired down causing the tire to rub? If that is the case then it would not be the manufactures responsibility to fix... Those are after market tires. Just get spacers on the tires or add more air if need...|
|03-24-2014 11:14 PM|
Get a lift....brake lines get relocated....problem solved and you get a lift!
|03-23-2014 02:04 PM|
|03-23-2014 01:42 PM|
Took a photo of the contact. This is from under the Jeep looking up while at left full lock.
|03-23-2014 08:09 AM|
Zombie Thread Alert! :-)
I wonder if the OP (or others) found the resolution to this. I happened to be checking under the Jeep as part of routine maintenance and noticed what I thought was rubbing in this location, but couldn't be sure.
Subsequent checks seem to reveal that, under hard left tuns, my driver's front tire makes contact with the foam/rubber collar which is zip-tied to the brake line.
I've got stock-sized tires (255/75R17 Firestone Destination AT) and no suspension modifications.
Not sure if it's related, but I've also noticed a steering wheel wobble under sharp turns... similar to when turning in 4WD, but not nearly as severe. I'm thinking a u-joint or ball joint, but I'm not sure. Either way, I'm calling a garage this week to have both issues looked into, but I'd love to know if there is a known cause and/or solution to the brake line rubbing.
|04-10-2011 08:52 AM|
|Salo||Same issue here...when I got oil change, I figured this was the k13 recall because it does not look normal..after having recall done at dealership, found out this is different non recall problem...BS!!!!!! Oh and during k13 fix, service guy said that my "ball joints have a lot of play on them"...I almost smacked him|
|04-09-2011 04:36 PM|
|Steel02001||To note I believe the $100 deductable you only have to pay once. I also have an extended service contract and was told that I would only have to pay the deductable once and from there one anything covered would be taken care of at no additional cost. I realize you dont want to spend the $100 but I would bet you are going to have too sooner or later, might as well get it out of the way. I've already paid mine.|
|04-09-2011 01:13 PM|
I believe that your front axle is not ok.
A friend of mine had a similar problem under warranty and after checking his front dana with a third party geometry expert it was revealed that his front axle had on the right end a deformation from its birth so to say. Dealer replaced its front axle entirely amd since then no rubber amy more.
Just a thought!
|04-09-2011 10:32 AM|
|bluefox||Contact the NHTSA dept. http://www.nhtsa.gov/|
|04-09-2011 08:52 AM|
|The Gila Monster||I had the front tires off of my wife's 2007 last night and discovered this same problem on both sides. I'm going to my local dealer now to see about a fix.|
|10-01-2010 06:41 PM|
|daggo66||I've never seen anyone post that issue on any of the forums.|
|10-01-2010 06:20 PM|
|dmevoli||If it was just my wrangler I would agree with you but I have checked 2 other 4 door sahara wranglers and they both have the same problem. Which is why I posted it here so that people will check their brake lines.|
|10-01-2010 05:25 PM|
|daggo66||OK, now that I have a better understanding I re-read your original post. It is a warranty type issue. Since your regular warranty is up and you have an extended warranty it will be covered by that with your $100 deductible. They shouldn't have to fix it for free. It is not a design defect that is affecting all Wranglers, it's just something wrong with yours.|
|10-01-2010 03:41 PM|
|dmevoli||Exactly. That is why I think they should fix the problem and not charge me.|
|10-01-2010 08:11 AM|
|daggo66||Something is wrong then because it shouldn't rub there at all.|
|10-01-2010 06:45 AM|
|dmevoli||it only rubs when the wheel is turned all the way to the left like pulling in and out of parking spaces.|
|09-30-2010 11:31 PM|
|daggo66||I still don't see how your tire is rubbing there. If it is then it's about to fall off.|
|09-30-2010 09:32 PM|
|Bladerunner32262||Good for you! I think you did the right thing. Chrysler sounds like apple, they won't admit their f*** ups. that's their own mistake and should be covered. Well, with the recall that is.|
|09-30-2010 09:28 PM|
|dmevoli||I will not do any mods until my warranty is over.|
|This thread has more than 30 replies. Click here to review the whole thread.|