Jeep Wrangler Forum banner
serpentine belt
1-18 of 18 Results
  1. YJ Tech Forum
    I have a 93 Jeep YJ, it is a Manual with the 4.0L- it shredded the serpentine belt (so I don't have the old to measure against), I have ordered 2 belts from parts stores = got 2 different sizes = I am convinced they have no clue about Jeep parts... simple fact is I can't get either fit. One is...
  2. YJ Tech Forum
    I have power steering pump 100% loose still can't get belt on. Grooves in belt also aligned with pulley ridges. Any ideas?
  3. JK Tech Forum
    I've had my new (to me) 2012 JK Sahara since 3/18/17. During the time I’ve had my baby, I have come to realize that her previous owner didn’t take care of her the way that I would have. About a week ago, I pulled up to a carwash to remove some grime from a light soft-roading trail and someone...
  4. TJ Tech Forum
    Hi all, I am back again with more Jeep trouble. To set the stage up, I've been having issues for the past several weeks with my Jeep. I've had a fairly high-pitched squealing coming from somewhere around my serpentine belt, my dad thinking that it was the tensioner. It increased in volume as my...
  5. TJ Tech Forum
    I was wondering if anyone could help with this I have a 12/99' Wrangler TJ and I'm trying to put on a new serpentine belt. Any diagram I can find on the route is always wrong because the Idler pulley sits down too close to the alternator and causes it to rub. I've managed to find bits of...
  6. YJ Tech Forum
    I need a harmonic balancer for my 89 YJ in V-belt, I have called all local auto shops, and searched extensively online with no luck. And I need to know if there are any serpentine conversion kits out there. any help would be appreciated :pcwhack:
  7. YJ Tech Forum
    I am looking for someone to post the correct belt tension from a service manual for a new serpentine belt. I do not want to put any more pressure on all of the components (alt, PS, water pmp…) bearings than I have to. I have seen allot of posts about having 1/2" of deflection in the belt and...
  8. TJ Tech Forum
    Hey guys, a few months ago while driving around in the snow in 4H all day, I threw my main serpentine belt off of one of the pullys on the engine. It shredded a bit off of one side along the whole belt and I would say it was at around 3/4 the width it should have been. I didnt think much of it...
  9. YJ Tech Forum
    I have a '95 I6 wrangler that has a really bad and constant (at idle and all RPMs). I replaced the belt so I'm sure its not that. A friend looked at it and believes its because the idler pulley is too loose. So my question is how to tighten it and/or do I need to replace it completely. Thanks...
  10. TJ General Discussion Forum
    Help :surrender:. I'm a newbie and have been browsing this forum a lot these last days. Last week, I started my Jeep TJ 1997 2.5L for the irst time in a month and was greeted by a deafening squeal. I decided to wait a bit to see if the noise will go softer but it didn't. I tried pushing on the...
  11. TJ General Discussion Forum
    Went to next shorter size, about 1 1/8th longer. Anybody ever have to do this? It lines up perfectly now with the I and II notches. I installed the recommended belt and it squealed like you wouldn't believe. Also, water temp seems a little lower (guess because the water pump is working ALL...
  12. TJ Tech Forum
    Just bought a used 2001 Wrangler Sport, 4.0 5 speed. Left turn signal turns off after turn, right signal 95% of the time doesn't. ALSO, serpentine belt looked a little worn so I changed it. LOTS of squealing. Removed belt and cleaned off pullies (really well too, turned crank a couple of...
  13. TJ Tech Forum
    I went wheelin in my 1998 tj the other day and it was still stock height and a lot of mud got underneath the hood ever since then my serpentine belt screams pretty loud and while im driving my check guages light comes on and my battery guage is all the way down to the red line but it doesnt die...
  14. YJ Tech Forum
    Hi all, I'm new here to the forum. I just picked up a 95 YJ with the 2.5L engine. I changed the serpentine belt today, and after changing it, the jeep has a whining sound. I can't tell if it's the adjuster pully, or the power steering pully. I do know the sound was not there before. Is it...
  15. YJ Tech Forum
    Hey peoples :wavey: So about 2 months ago I replaced my alternator belt, piece of cake, loosen the alternator mount and the belt comes right off. Now the power steering pump is starting to squeal, so I go to loosen the power steering pump mount...WRONG! How the heck do you get that belt off...
  16. YJ Tech Forum
    Hey all, I just changed the water pump on my 95 2.5L and now I can't get the serpentine belt back on. My Jeep uses the PS pump as the tensioner. I loosened both bolts on back and on front and adjusted the tensioner screw that screws out toward the driver side fender. Even when I pull the PS...
  17. YJ Tech Forum
    The belt on my 95 is squeaking, it appears to be in good shape but it is not super tight. How do i tighten it, making sure not do do any damage to anything?
  18. TJ Tech Forum
    I was driving home from North Conway and my friend was feeling cold water occasionally fall onto his feet in the passenger seat. I didnt think to much of it we had lots of gear all over the place it was all pretty soaked. I was about 100 miles into the trip when a horrible smell took over the...
1-18 of 18 Results
Top