Search Results for ‘transfer case’

My Ol' Jee was making what sounded like chain-slap from the transfer case. Has 163k miles, so my buddy and I disassembled the transfer case to replace the chain. Old and new chain were identical in length. Oh oh. So we still put in the new chain and new seals. Re-assembled. But now top speed on...

Hi everyone- Can someone please verify for what year Jeep Wrangler this NP231 transfer case is? Also is it for a manual or automatic transmission? The tag reads 231 J | 5209 9364 | 8 7 97 1 | 272 The stencil on the actual housing reads C-16117AP 09104. There's also a stencil with a number 12...

Hi all, My JLUR is my first off-road 4x4 and I am new to 4WD. I have been wheeling a couple of times already, and my way of shifting from 2H to 4H is taking my foot off of the brake and pulling the shifter down to 4H. I thought on the manual, you can shift it while parked or rolling, so I think...

Here’s a link to my first “how-to” video, let me know what you all think!

I have a manual 2012 Sport Unlimited and got stuck in the mud today. It has a 3.5 lift and 35’s. The person who helped me get out burned my clutch to the point where there was an intense amount of smoke coming from the bottom. After he couldn’t get me out through that he just pulled me out. Now...

So I pulled the transfer case (NP231) to replace seals and inspect that all of the components were intact and working. After watching multiple how to videos it seemed simple enough. However, I am stuck. I can't get the housing around what I think is the oil pump (also where the speedo sensor...

Hi all! Not new to the jeep world or engaging 4 wheel drive-I just traded my '13 JKU for a built '05 TJ. From what I'm reading in the manual, the jeep is currently in 4h(upward position) but when I put it into 2h(downward postion) the 4 wheel drive light goes on. Any idea why this is happening...

Hi Everyone, im a new member and a new TJ owner as well, so excuse me for any silly questions :)) After installing a Rough country 4" lift on my TJ with RC unadjustable lower arms, but stock upper arms, i started having vibrations, so i installed a SYE to eliminate it, it works perfectly...

Recently had a rebuilt short block installed due to a main bearing blow-out. After getting the Jeep back, auto transmission shifter became inoperable and found the cable clip at the transmission had broken; no problem, just replaced the clip and away I go. Now, went to use 4W drive and shifter...

Hello, I'm curious if wrangler transfer case bolt patterns and splines are the same. Specifically, a 2020 Rubicon transfer case into a 1995 YJ.

Well, to keep this short--this whole project started as a simple fluid change for my diffs and t case. Unfortunately, the dealer that did my last t case fluid change must have used an impact on the fill plug as it was stripped seized on. This turned into removing front and rear driveshafts...

At about 20mph I tried to switch to 4hi in my 2012 jk and it slipped all the way into neutral and made a grinding sound for a second but went away. Once I stopped i tested our 4hi and 4lo they both worked but i was wondering if i caused and damage? Any thoughts?

This is our first Jeep and we need it as a flat tow vehicle for RV trips. Because it's our first I make certain I follow the manual very carefully (even doing the extra steps to verify the vehicle will not move when transfer case is in neutral). When I have the transfer case in neutral and I...

I own a '06 TJ, 6 speed manual transmission. I had a SYE installed over a year ago and it fried something in my TC. I will need a replacement. To have a shop rebuild a new TC with a SYE will cost me a lot. Quadratec.com sells TCs with SYE kit already installed but only ones that fit the AX-15...

Looking for a main shaft for an '87-90 NP231 transfer case. P.N. 83503141 Good Luck, L.M.

Hi all Looking to change out transfer case and transmission for something better(I messed mine while on some trails) Recommendations or do I get the stock 32RH and tc rebuilt? 98 Sahara 6cyl

Noticed this after going for a short drive. What am I looking at here? engine oil/transfer case leak? how serious is this and how easy/difficult is it to fix? I marked the spots where I can see the oil dripping from.

Hey all, so, I've got a dilemma; I have a 1993 Wrangler (I6, manual 3 inch shackle lift and 3 inch body lift) Recently I went over a deer and it busted my transfer case open and destroyed my rear drive shaft. My transfer case, I believe is a 241J, but I cannot for the life of me find one that...

Hi, I have 2018 JKUR with manual transmission. Have rattle coming from transfer case shifter during acceleration since 20k mi. Tried to show it to dealer on 2 separate visits, dealer unable to replicate. Noise disappears after pushing transfer case lever to the right and to the rear just before...